Featured Post

October 2 - Meetings, Grading and Pews

Image
Another Status Meeting in the Church - A week ago Sunday the second status update meeting was held at the church. While there were some assembled pews, they were all in the sanctuary, and not in the dining hall where the meeting convened. So, everyone that wanted to sit had to bring their own chair. In the picture, Bob is standing but not because he failed to bring a chair. He wanted attention so he stood up in the front to give his status update. After Sam reported on the finances discussion ensued about whether or not to increase our self imposed debt ceiling. While the church could be 'completed' without the increase, some desired items like an epoxy sealed kitchen floor would have to be deferred. The congregation agreed to up the debt limit. Sam stated that the bank is fine with the new debt ceiling. Sam also said the projection stand in the picture is only temporary. With the current projected spending, we will still not have a completed kitchen so the eagle-eyed shoppers ...
Post a Comment

July 30 - Filling the Foam Walls with Concrete

Once the foam block walls are in place, the interior is filled with concrete. No wheel barrows and garden trowels for this job. We need a real live concrete pumper truck. Yep, one that pumps concrete up in the air about a hundred feet or so and then lets the mud free fall down a hose that must be guided to the holes to be filled.
The concrete pumper is a rather majestic looking beast with a long, graceful neck that reminds me of a swan. The truck was only moved once and from those two positions the boom was able to fill the entire perimeter of the building.





The truck driver and pump operator controlled the movement of the boom and the flow of the concrete from a wireless remote that was belted around his waist.  

















Mark Vonada slalomed the hose around the protruding rebar trying to put as much as possible inside the blocks while dumping as little as possible on the outside. Mark seemed to think it was important that he not let go of the hose when it was full of concrete and under pressure. I tend to agree with his view on this subject as I suspect this setup could put a lot of concrete where it is not wanted in a hurry if left untended.



























When the mud flows, a lot of folks are real busy. Some are poking and prodding the mud with sticks while others are using hammers to beat on the wall. Both jobs are needed to settle the concrete into the foam blocks and eliminate voids. The pounders use flat boards to protect the foam from direct hammer strikes. The prodders and pokers use about any piece of lumber they can find. In the door openings where the top of the wall is the final height for that section, the top is troweled somewhat smoother. Frenetic activity abounds at those moments. As the photographer tried to stay in close to capture this image, Mark suggested that he may want to find a position a little more removed from the action. As the stream of concrete approached, I quickly came to agree with his judgment.










On one wall, it was necessary to pour part of the footing as the wall above it was being filled. This seemed to go well but a while later someone noticed the wall bulging a bit on the side with the freshly poured footing. This seemed to be a matter of some urgency and many folks joined in putting their energy into battling against the bulge. Another board was added at the top of the wall and the bracing boards shifted to help move the wall back into its proper position.






This picture shows Ken Wuollet using a size large 2x4 as a lever. This seemed to help considerably as the wall decided to resume its original and upright position, just like the seat backs on airplanes during take off and landing. It is fortunate that Ken stayed awake that  day in physics class when Archimedes and his lever was discussed.















 Dan Hillukka sights approvingly down the adjusted wall which has now been pushed and prodded upright again and held in place with more bracing boards. 

So the walls are above final grade level and the back filling both inside and outside can now begin. It is a little bit sad that nearly all of the work done to this date will be covered by dirt and will not have a chance to be admired. So, take a good look now.

Comments

Post a Comment

Popular Posts

February 17 - Pouring the Floor, Part 2

Image
Pouring it On Sweatshirts and jackets came off as the morning wore on, the temperature rose, and that heavy concrete hose was dragged all over the church.  When I returned to the church at about 11:30 that morning, I saw the last of the concrete truck parade.  One truck was emptying its load, another was cleaning up, and a third was pulling away to return to home base. Inside was a surprise -- the floor was almost finished!  The last of the narthex, office, coat room, and mechanical room was being poured.  Here you can see the power screeding machine in action again.  The reference laser it uses can be seen in the distance, fastened high on the door jamb leading to the sanctuary, visible just above Brian's head. By now, everyone seemed to know exactly what to do and when to do it. The pump outside is controlled remotely by Jeff Wikman, via the yellow control box he's holding.  While Mark directs the hose, Jeff monitors the progress, ready to stop the pump i...
Read more

October 2 - Meetings, Grading and Pews

Image
Another Status Meeting in the Church - A week ago Sunday the second status update meeting was held at the church. While there were some assembled pews, they were all in the sanctuary, and not in the dining hall where the meeting convened. So, everyone that wanted to sit had to bring their own chair. In the picture, Bob is standing but not because he failed to bring a chair. He wanted attention so he stood up in the front to give his status update. After Sam reported on the finances discussion ensued about whether or not to increase our self imposed debt ceiling. While the church could be 'completed' without the increase, some desired items like an epoxy sealed kitchen floor would have to be deferred. The congregation agreed to up the debt limit. Sam stated that the bank is fine with the new debt ceiling. Sam also said the projection stand in the picture is only temporary. With the current projected spending, we will still not have a completed kitchen so the eagle-eyed shoppers ...
Read more

September 25 - Last Saturday: A Really Big Day

Image
Concrete Pour -  Another concrete pour, this time the sidewalks across the front and the walk under the portico. Two truckloads of mud got all the sidewalk done and half of the dumpster pad beyond the back edge of the parking lot. Sonny Johnson, Phil Johnson and Charlie Halonen from the Minneapolis congregation as well as Dale Muhonen from Rockford volunteered to help with the job. Once again, a helping hand from the neighboring congregations is greatly appreciated. It is always fascinating to watch this work - when the truck is spilling its contents, many hands and feet are required to coax the heavy goo into its desired location. Phil is shown pushing the goo around while Sonny and Dale operate the screed. After the concrete is leveled out, the bull float is used to smooth the surface. The float may reveal a spot lacking just a little material so the master adds a shovelful here and there to make sure the surface is just right. After the mix has a chance to set up a bit, the red ...
Read more